P1604 · Herstellerinformationen

TOYOTA · 2020-01-23

TSB: REVISION NOTICE January 23, 2020 Rev1: G1439 The Parts Information, Calibration Information, and Repair Procedure sections have been updated. SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0058-13.Service Bulletin No. T-SB-0058-13 is obsolete and any printed versions should be discarded. Some 2009 ? 2018 model year Sequoia and 2009 ? 2019 model year Tundra vehicles equipped with a 3UR-FBE engine may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ? DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ? DTC P0172 and/or P0175 (System Too Rich Bank 1/Bank 2) ? DTC P1604 (Startability Malfunction) Techstream data list analysis may reveal negative fuel trims and an…

TOYOTA · 2019-12-06

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0058-13. Service Bulletin No. T-SB-0058-13 is obsolete and any printed versions should be discarded. Some 2009 ? 2018 model year Sequoia and 2009 ? 2019 model year Tundra vehicles equipped with a 3UR-FBE engine may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs). ? DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ? DTC P0172 and/or P0175 (System Too Rich Bank 1/Bank 2) ? DTC P1604 (Startability Malfunction) Techstream Data List analysis may reveal negative fuel trims and an elevated alcohol density estimate relative to the vehicle?s actual fuel alcohol content. Follow the Repair Procedure in this bulletin to address…

SUBARU · 2019-10-25

This bulletin announces availability of reprogramming files to optimize the Engine Control Module (ECM). The new files will address isolated concerns of an extended cranking (hard starting) condition. They will also address a DTC P1604 which may be stored in the ECM memory without illuminating the Check Engine light.

TOYOTA · 2019-06-24

TSB: Some 2014 ? 2018 model year Highlander and Highlander Hybrid vehicles may exhibit one or more of the following conditions. ? Various drivability concerns ? Low or no fuel pressure ? Diagnostic Trouble Codes (DTCs) (Including but not limited to P1603, P1604, P1605, P0171, P0300, P0302, P0304, U0100) ? Some 2014 ? 2018 model year Highlander Hybrid vehicles may exhibit DTC P134A. These conditions may be caused by corrosion/water in the A43 ECM connector (Highlander) or the A9 inverter water pump connector (Highlander HV). The corrosion in the A43 and A9 connectors is due to poorly sealed or damaged aftermarket windshield deicer harnesses. Follow the Repair Procedure in this bulletin to address these conditions.

TOYOTA · 2017-11-14

T-TT: Vehicles may experience various drivability concerns. Upon diagnosis, technicians commonly find no or low fuel pressure as well as a variety of DTCs (Commonly P1603, P1604, P1605, P0171, P0300, P0302, P0304, U0100). Technicians find that the cause this condition is corrosion and water in the A43 ECM connector (Fig 1). In several cases, it was found that the source of water was from aftermarket windshields with poorly sealed or damaged deicer harnesses (Fig 2). Water enters the deicer harness and is wicked through the engine room main harness, eventually collecting in the ECM connector.

SCION · 2016-10-20

TSB: Some 2012 ? 2013 model year iQ vehicles may exhibit one or more of the following conditions: * Rough idle condition. * Idle speed momentarily drops at idle. * MIL ?ON? with one or more of the following DTCs: P1603, P1604 and/or P1605. These may be caused by excessive carbon build-up on piston head. Follow the Repair Procedure in this Service Bulletin to address this condition

HINO · 2016-10-05

If a 2013 - 17 COE model 195h is encountered with a will not move in any gear condition and any combination of DTC'S P0706, P0756, P0761, P1604, please perform the following for engineering review.

HINO · 2016-10-05

SB-15-048 If a 2013-2017 COE model 195h is encountered with a will not move in any gear condition and any combination of DTC's P0706, P0756, P0761, P1604, please perform the following for engineering review.

HINO · 2015-03-19

A subject vehicle may exhibit an illuminated Malfunction Indicator Lamp (MIL) on and a code P1604 stored in the Transmission Control Module.

HINO · 2015-03-19

SB-14-006 COE Diesel and Hybrid P1604 Code Procedure. A subject vehicle may exhibit an illuminated Malfunction Indicator Lamp (MIL) on and a code P1604 stored in the Transmission Control Module.

HINO · 2015-01-20

SB-15-010 Some vehicles that operate in extreme cold weather climates may exhibit ice accumulation on the EGR (Exhaust Gas Recirculation) butterfly plate with a repeat P1604 DTC (Diagnostic Trouble Code) stored in the engine ECU. A heated EGR valve has been made available to prevent this occurrence.

TOYOTA · 2014-12-11

TSB: Some 2012 ? 2015 model year Sequoia and Tundra vehicles with the 3UR-FBE engine may exhibit a MIL ?ON? condition with Diagnostic Trouble Codes (DTCs) P0171/P0174 (System too Lean Bank 1/Bank 2), P0172/P0175 (System too Rich Bank 1/Bank 2), P1604 (Startability Malfunction), and/or P1605 (Rough Idling) after attempting to start the engine. Alcohol Density Estimate values may be high even though the vehicle was fueled with regular fuel (E0/E10). The Engine Control Module/ECM (SAE term: Powertrain Control Module/PCM) logic has been modified to address this condition. Use the following Repair Procedure to reprogram the ECM (PCM). ©

TOYOTA · 2014-12-11

TSB: Some 2012 ? 2015 model year Sequoia and Tundra vehicles with the 3UR-FBE engine may exhibit a MIL ?ON? condition with Diagnostic Trouble Codes (DTCs) P0171/P0174 (System too Lean Bank 1/ Bank 2), P0172/P0175 (System too Rich Bank 1/Bank 2), P1604 (Startability Malfunction), and/or P1605 (Rough Idling) after attempting to start the engine. Alcohol Density Estimate values may be high even though the vehicle was fueled with regular fuel (E0/E10). The Engine Control Module/ECM (SAE term: Powertrain Control Module/PCM) logic has been modified to address this condition. Use the following Repair Procedure to reprogram the ECM (PCM). ©

HINO · 2014-01-20

Some vehicles that operate in extreme cold weather climates may exhibit ice accumulation on the EGR (Exhaust Gas Recirculation) butterfly plate with a repeat P1604 DTC (Diagnostic Trouble Code) stored in the engine ECU. A heated EGR valve has been made available to prevent this occurrence. Hino Conventional NE8J, NJ8J and NV8J trucks built before 10/15/2014

TOYOTA · 2013-06-06

Some 2012 ? 2013 model year Sequoia and Tundra vehicles with the 3UR-FBE engine may exhibit a MIL ?ON? condition with Diagnostic Trouble Codes (DTCs) P0171/P0174 (System too Lean Bank 1/ Bank 2), P0172/P0175 (System too Rich Bank 1/Bank 2), P1604 (Startability Malfunction), and/or P1605 (Rough Idling) after attempting to start the engine. Alcohol Density Estimate values may be high even though the vehicle was fueled with regular fuel (E0/E10). The Engine Control Module/ECM (SAE term: Powertrain Control Module/PCM) logic has been modified to address this condition. Use the following Repair Procedure to reprogram the ECM (PCM).

TOYOTA · 2013-04-26

Some 2012-2013 model year Sequoia and Tundra vehicles with the 3UR-FBE engine may exhibit a MIL "ON" condition with DTC P0171/P0174 (lean), P0172/P0175 (rich), P1604 Startability, and/or P1605 Rough Idle after attempting to start the engine.

CHRYSLER, DODGE · 2003-09-12

ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP ILLUMINATION WITH FALSE DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0116, P0335, P0339, P0340, P0462, P0498, P0499, P0522, P0622, P1604, P1681, P1686, P1698. *TT

CHRYSLER, DODGE · 2002-10-28

A MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE WITH ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0335, P0339, P0340, P0462, P0498, P0499, P0622, P1604, P1681, P1686. *TT

CHRYSLER, DODGE · 2002-10-07

ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0016, P0335, P0339, P0340, P0462, P0498, P0499, P0522, P0622, P1604, P1681, P1686. *TT

CHRYSLER, DODGE · 2002-10-01

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE DUE TO ERRONEOUS DETECTION DIAGNOSTIC TROUBLE CODES (DTC) P0335, P0340, P0462, P0499, P0622, P0660, P1604, P1681, P1698. *TT