P0420 · 原廠技術資料

BUICK · 2025-01-09

This service bulletin provides information for dealers/technicians on DTC P0420 Setting.

HONDA · 2025-01-09

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Effciency Below Threshold] stored. To better understand the cause of this condition, AHM would like to specific parts from the vehicle prior to you attempting a repair of any kind.

MERCEDES-BENZ · 2024-12-20

Complaint Check engine light illuminated. Fault code P042000 Current or stored in MRG2 control unit. Cause Catalytic converter not operating efficiently Remedy Replace catalytic converter. Note: Additional hardware replacement is not needed unless other symptoms are present. If there are other faults relating to engine operation, diagnose these separately.

DODGE · 2024-12-19

"Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0420 - Catalyst System Efficiency Below Threshold Bank 1. ● P0430 - Catalyst System Efficiency Below Threshold Bank 2.** ● P0456 - EVAP System Small Leak. NOTE: If DTC P0456 is present use the wiTECH Small Leak Verification test (SLVT) to determine if a leak is present in the system. This bulletin involves reprogramming the PCM with the latest available software."

CHRYSLER · 2024-12-19

"Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0420 - Catalyst System Efficiency Below Threshold Bank 1. ● P0430 - Catalyst System Efficiency Below Threshold Bank 2.** ● P0456 - EVAP System Small Leak. NOTE: If DTC P0456 is present use the wiTECH Small Leak Verification test (SLVT) to determine if a leak is present in the system. This bulletin involves reprogramming the PCM with the latest available software."

HONDA · 2024-12-03

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2024 Accord 1.5Ls, 2021-2024 Civics 1.5Ls, 2023-2024 CR-Vs 1.5Ls, and 2017 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Efficiency Below Threshold] stored. To better understand the cause of this condition, AHM would like to specific parts from the vehicle prior to you attempting a repair of any kind.

HONDA · 2024-11-05

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2024 Accord 1.5Ls, 2021-2024 Civics 1.5Ls, 2023-2024 CR-Vs 1.5Ls, and 2017 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Effciency Below Threshold] stored. To better understand the cause of this condition, AHM would like to specific parts from the vehicle prior to you attempting a repair of any kind.

HONDA · 2024-10-23

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Effciency Below Threshold] stored. To better understand the cause of this condition, AHM would like to specific parts from the vehicle prior to you attempting a repair of any kind.

KIA · 2024-10-18

SUBSEQUENT REPAIR ACTION: CATALYTIC CONVERTER REPLACEMENT AND ENGINE INSPECTION/REPLACEMENT (SC176Y) - This bulletin provides catalytic converter and engine sub-assembly diagnosis and repair information on certain 2012-2016MY Soul (AM, PS) vehicles produced from July 8, 2011 through August 11, 2016, that previously had the recall campaign SC176 completed. The affected vehicles may exhibit catalyst system efficiency deterioration or a malfunction indicator lamp illumination with an active, history or pending P0420 with or without a P030X misfire DTC.

FORD · 2024-10-04

The affected vehicles have an on-board diagnostics (OBD) system that may falsely set the catalytic converter Diagnostic Trouble Codes (DTC) P0420 – Catalyst System Efficiency Below Threshold (Bank 1) and/or P0430 – Catalyst System Efficiency Below Threshold (Bank 2), causing the Malfunction Indicator Light (MIL) to illuminate even though a repair may be unnecessary

HONDA · 2024-10-02

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Effciency Below Threshold] stored. To better understand the cause of this condition, AHM would like to specific parts from the vehicle prior to you attempting a repair of any kind.

HONDA · 2024-09-17

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Effciency Below Threshold] stored. To better understand the cause of this condition, AHM would like to specific parts from the vehicle prior to you attempting a repair of any kind.

FORD · 2024-08-05

2020 Model Year Explorer and Explorer Police Interceptor - Utility Equipped with a 3.3L Engine Replace Catalytic Converters for Diagnostic Trouble Code (DTC) P0420 or P0430 and Inspect Wire Harness for Runs Rough/Misfire Condition Reason for Supplement: additional information on reason for repair, labor allowances and technician information.

DODGE · 2024-07-17

Spark Plug Re-Gap to Resolve Misfire Symptoms Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0300 - Multiple Cylinder Misfire. ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P0305 - Cylinder 5 Misfire. ● P0306 - Cylinder 6 Misfire. ● P0307 - Cylinder 7 Misfire. ● P0308 - Cylinder 8 Misfire. ● P0420 - Catalyst System Efficiency Below Threshold Bank 1. ● P0430 - Catalyst System Efficiency Below Threshold Bank 2. The customer may also comment on one or more of the following: ● Excessive vibration. ● Engine runs rough. ● Lack, or loss of power. ● Engine misfire.

FORD · 2024-06-13

2020 Model Year Explorer and Explorer Police Utility Equipped with a 3.3L Engine Replace Catalytic Converters If Failed and Inspect Wire Harness In some of the affected vehicles, one or both of the catalytic converters may develop outer cracks or inner heat-related damage. If a catalytic converter fails, then the Malfunction Indicator Light (MIL) may illuminate and diagnostic trouble codes (DTCs) P0420 or P0430 will be stored in the Powertrain Control Module.

FORD · 2024-06-07

This article supersedes TSB 24-2115 to update the Service Procedure. Some 2018-2020 F-150 vehicles equipped with a 2.7L EcoBoost may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to calibration and controls sensitivity. To correct the condition, follow the Service Procedure to perform the catalyst stabilization drive cycle.

HONDA · 2024-05-03

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Efficiency Below Threshold] stored. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to your attempting a repair of any kind.

FORD · 2024-04-26

This article supersedes TSB 23-2425 to address revised software and update the Parts List. Some 2022-2023 F-150 hybrid vehicles equipped with a 3.5L PowerBoost engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to calibration and controls sensitivity. To correct the condition, follow the Service Procedure to reprogram the PCM and perform the catalyst stabilization drive cycle.

FORD · 2024-04-24

This article supersedes TSB 22-2260 to update the vehicle applications. Some 2018-2020 F-150 vehicles equipped with a 2.7L EcoBoost may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to calibration and controls sensitivity.

HONDA · 2024-04-15

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Efficiency Below Threshold] stored. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to your attempting a repair of any kind.

AUDI · 2024-04-04

Noise from front door trim panel while driving Air suspension warning - DTC P089200 charge handle doesn't release vehicle will not charge Corrosion on wheelhouse cover plate P008700 - low fuel pressure P042000: Catalyst System,Bank1 Efficiency Below U060B00 - no com to G31 boost pressure sensor Airbag light on, DTCs B101704, B103604 Wind noise from front doors at highway speeds

AUDI · 2024-04-04

Noise from front door trim panel while driving Air suspension warning - DTC P089200 charge handle doesn't release vehicle will not charge Corrosion on wheelhouse cover plate P008700 - low fuel pressure P042000: Catalyst System,Bank1 Efficiency Below U060B00 - no com to G31 boost pressure sensor Airbag light on, DTCs B101704, B103604 Water intrusion from sunroof Wind noise from front doors at highway speeds

HONDA · 2024-03-28

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 [Catalyst System Efficiency Below Threshold] stored. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to your attempting a repair of any kind.

AUDI · 2024-03-05

Noise from front door trim panel while driving Low coolant warning in cluster, coolant level is correct Front window inoperative Air suspension warning - DTC P089200 charge handle doesn't release vehicle will not charge Temp sensor DTC P218500 Corrosion on wheelhouse cover plate P008700 - low fuel pressure P042000: Catalyst System, Bank1 Efficiency Below

HONDA · 2024-02-15

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017-2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 (Catalyst System Efficiency Below Threshold) stored. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to your attempting a repair of any kind.

HONDA · 2024-02-01

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017-2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 (Catalyst System Efficiency Below Threshold) stored. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to your attempting a repair of any kind.

HONDA · 2024-01-17

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017-2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 (Catalyst System Efficiency Below Threshold) stored. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to your attempting a repair of any kind.

HONDA · 2024-01-02

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2017-2018 Fits with customer complaint of Check Engine Light (CEL) on with DTC P0420 (Catalyst System Efficiency Below Threshold) stored. To better understand the cause of this condition, AHM would like to collect specific parts from the vehicle prior to your attempting a repair of any kind.

FORD · 2023-12-20

This article supersedes TSB 23-2337 to update the Service Procedure and the causal part. Some 2022-2023 F-150 hybrid vehicles equipped with a 3.5L PowerBoost engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to high sulfur content in the fuel. To correct the condition, follow the Service Procedure to reprogram the PCM and remove sulfur from the catalytic converters.

CHEVROLET · 2023-12-13

Special Coverage: On certain vehicles, the diesel particulate filter (DPF) fuel injector may fail, setting Diagnostic Trouble Code (DTC) P0420 in the Engine Control Module (ECM). If this occurs, the Malfunction Indicator Lamp (Check Engine Light) will illuminate. If the DPF injector is determined to have failed, dealers are to replace the DPF fuel injector. The repairs will be made at no charge to the customer.