P0455 · 原廠技術資料

ACURA · 2026-09-25

Service Bulletin - The factory fuel fill pipe assembly may not have been manufactured to specification. As a result, small contamination particles inside the fuel fill neck may prevent the primary shut-off valve flap seal from sealing properly. This may result in a fuel smell from the fuel fill neck area and may cause DTC P0455 or P0456 (EVAP system leak detected) to be set.

ACURA · 2026-09-25

Service Bulletin - The factory fuel fill pipe assembly may not have been manufactured to specification. As a result, small contamination particles inside the fuel fill neck may prevent the primary shut-off valve flap seal from sealing properly. This may result in a fuel smell from the fuel fill neck area and may cause DTC P0455 or P0456 (EVAP system leak detected) to be set.

ACURA · 2026-09-25

Dealer Message - The fuel fill pipe assembly may not have been manufactured to specification. As a result, small contamination particles inside the fuel fill neck may prevent the primary shut-off valve flap seal from sealing, resulting in fuel smell from the fuel fill neck area and may cause DTC P0455 or P0456 (EVAP system leak detected) to be set.

FORD · 2025-09-13

*This article supersedes TSB 24-2199 to add the rear half shaft seals to the TSB parts list. Some of the vehicles listed in the model statement above may exhibit one of the following conditions: *Fuel tank not filling up beyond half-full *Hard to start *Stalls upon restart after refueling *A malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P04F0, P0451, P0455, and/or P0496 may also be stored in the powertrain control module (PCM) This may be due to a disconnected fuel vapor line inside the fuel tank. Additional Model Information: All Wheel Drive (AWD).

FORD · 2025-08-20

Some of the vehicles listed in the Model statement above may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0455, P0456, P0442 and/or P04EE. This may be due to a chaffing or rubbing condition between the fuel vapor canister line and the air vent hose.

CHEVROLET, GMC · 2025-03-13

This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.

CHEVROLET, GMC · 2024-10-07

This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.

FORD · 2024-07-02

Some 2024 Edge vehicles equipped with a 2.0L engine and all-wheel drive (AWD) may experience the fuel tank not filling up beyond half-full, hard to start, and/or stalls upon restart after refueling. A malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P04F0, P0451, P0455, and/or P0496 may also be stored in the powertrain control module (PCM). This may be due to a disconnected fuel vapor line inside the fuel tank. To correct the condition, follow the Service Procedure to reattach the fuel tank vapor line inside the fuel tank.

CHEVROLET, GMC · 2024-02-26

This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.

CHEVROLET, GMC · 2023-09-20

This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.

DODGE · 2023-08-29

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General Evap System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

DODGE · 2023-08-29

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General Evap System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

DODGE · 2023-08-29

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General Evap System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

CHRYSLER · 2023-08-16

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General Evap System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

DODGE · 2023-08-16

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General Evap System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

DODGE · 2023-08-16

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General EVAP System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

DODGE · 2023-08-16

Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0455 - EVAP System Large Leak. ? P0456 - EVAP System Small Leak. ? P0440 - General EVAP System Failure. ? P0441 - EVAP Purge System Performance. This bulletin involves reprogramming the PCM with the latest available software.

CHEVROLET, GMC · 2023-06-19

This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.

FORD · 2023-06-15

Some 2021-2023 F-Super Duty/E-Series vehicles equipped with a 6.2L, 6.8L or 7.3L gasoline engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0457 and/or P0455 stored in the powertrain control module (PCM). This may be due to a improper fuel filler cap installation and/or outside contamination on the fuel cap sealing surface. The fuel filler cap requires multiple turns to seal properly and should be clean of any debris on sealing surface. Advise the customer to turn the fuel filler cap clockwise until there is at least one audible click to seal properly. If the DTCs return after the fuel filler cap is cleared of debris and properly seated, refer to Workshop Manual (WSM), Section 303-13 > pinpoint test HX.

BUICK, CADILLAC, CHEVROLET, GEO, GMC · 2022-12-14

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

FORD · 2022-12-12

Some 2020-2022 Explorer vehicles equipped with a 2.3L engine may exhibit an illuminated malfunction indicator lamp (MIL) with multiple diagnostic trouble codes (DTCs). These DTCs may include P04F0, P008A, P0451, P0455, P0456, P0496 and/or P018C. This may be due to the wiring harness connection at connector C1198 on driver's side lower frame area underneath the brake lines that route near the electric brake booster (EBB). Prior to replacement of any components, inspect the connector and wiring harness for any damage or pin fit concerns. If any damage or pin fit concerns are found, repair the connector or harness as necessary. If no damage or pin fit concerns are found, refer to normal diagnostics. Refer to Wiring Diagram (WD) Cell 22-12 to view the 3 voltage reference (VREF) wires at C1198…

FORD · 2022-10-14

Some 2020-2022 Explorer vehicles equipped with a 2.3L engine may exhibit an illuminated malfunction indicator lamp (MIL) with multiple diagnostic trouble codes (DTCs). These DTCs may include P04F0, P008A, P0451, P0455, P0456, P0496 and/or P018C. This may be due to the wiring harness connection at connector C1198. Prior to replacement of any components, inspect the connector and wiring harness for any damage or pin fit concerns. If any damage or pin fit concerns are found, repair the connector or harness as necessary. If no damage or pin fit concerns are found, refer to normal diagnostics.

ACURA · 2022-09-22

"Service Bulletin - The MIL comes on with DTC P0455 (Evaporative Emission [EVAP] System Very Large Leak Detected) stored. The fuel main flap unit may have stuck open, causing a DTC to set."

ACURA · 2022-09-02

Dealer message - The MIL comes on with DTC P0455 (Evaporative Emission [EVAP] System Very Large Leak Detected) stored. The fuel main flap unit may have stuck open, causing a DTC to set.

DODGE, JEEP, RAM · 2022-08-12

Updated Fuel Filler Cap This bulletin involves updating the fuel filler cap with improved version. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: P0455 - EVAP System Large Leak. P0456 - EVAP System Small Leak. P04EC - EVAP System Large Leak Detected - Fuel Tank Side. P04EE - EVAP System Very Small Leak Detected - Fuel Tank Side.

DODGE · 2022-04-07

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or moreof the following DTCs have been set: P0452 - EVAP Pressure Switch Stuck Closed. P0455 - EVAP System Large Leak. P0440 - General EVAP System Failure. P0456 - EVAP System Small Leak.If DTC P0456 is present use the wiTECH Small Leak VerificationTest (SLVT) to determine if a leak is present in the system. Customers may also comment on one or more of the following: Vehicle will fail to start when cold at times. Noise heard from the drivetrain while stationary and vehicle is in Sport/Track modes.

DODGE · 2022-03-31

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or moreof the following DTCs have been set: P0452 - EVAP Pressure Switch Stuck Closed. P0455 - EVAP System Large Leak. P0440 - General EVAP System Failure. P0456 - EVAP System Small Leak.If DTC P0456 is present use the wiTECH Small Leak Verification Test (SLVT)to determine if a leak is present in the system. Customers may also experience one or more of the following: Vehicle will fail to start when cold at times. A noise heard from the drivetrain while stationary and vehicle is inSport/Track modes. Extended engine crank times.

DODGE · 2022-03-31

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or moreof the following DTCs have been set: P0452 - EVAP Pressure Switch Stuck Closed. P0455 - EVAP System Large Leak. P0440 - General EVAP System Failure. P0456 - EVAP System Small Leak.If DTC P0456 is present use the wiTECH Small Leak Verification test (SLVT) to determine if a leak is present in the system. Customers may also experience the following:Vehicle willfail to start when cold at times. Noise heard from the drivetrain while stationary and vehicle is in Sport/Trackmodes. Extended engine crank times.

DODGE · 2022-03-31

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or moreof the following DTCs have been set: P0452 - EVAP Pressure Switch Stuck Closed. P0455 - EVAP System Large Leak. P0440 - General EVAP System Failure. P0456 - EVAP System Small Leak.If DTC P0456 is present use the wiTECH Small Leak Verification test (SLVT) to determine if a leak is present in the system. Customers may also experience one or more of the following: Vehicle will fail to start when cold at times. Noise heard from the drivetrain while stationary and vehicle is in Sport/Trackmodes. Extended engine crank times.

NISSAN · 2022-02-07

EVAP LEAK DTC P0442, P0455, P0456 INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.